Welcome to ATE! Call us:

+86-21-58386189, 58386176

replacement of sand by marble powder pdf

Replacement of Fine Aggregates by Mixture of Ceramic and ...

ceramic and marble powder the compressive and tensile strength of the concrete mix increased, with its maximum value at full replacement of conventional fine aggregate by ceramic and marble powder. Keywords: Compressive strength, Split cylinder test, Slump test, Water-Cement ratio, Ceramic and marble mixture, Mix design.

Influence of Marble Dust as Partial Replacement of Cement ...

the performance of concretes contained marble dust as a cement replacement, mix was prepared with cement and sand blended with marble dust with replacement from 10%, 20%, 25% and 30%.The investigation indicates that replacement of cement by marble waste powder at …

Marble powder - SlideShare

Sep 11, 2016· • In marble quarries, stones are cut as blocks through different methods • During the cutting process, 20-30% of a marble block becomes waste marble powder.Marble powder is a waste material generated in considerable amounts in the world • Marble waste leads to a serious environmental problem as well • Hence the reuse of waste material ...

Replacement of cement and sand in concrete with Waste ...

marble dust powder or marble waste products. But the combination of replacement of 10% of cement and 10% of sand with marble dust powder or marble waste product, the strength get start to decrease. So that the 20% of combination of cement and sand cannot be replaced by marble waste product or marble dust powder.

PARTIAL REPLACEMENT OF FINE AGGREGATE BY MARBLE …

From the above study, it is concluded that the marble slurry can be used as a replacement material for sand; and 25% replacement of marble slurry gives an excellent result in strength aspect and quality aspect and it is better than the control concrete. The results showed that the substitution of 25% of the sand content by marble stone

(PDF) UTILIZATION OF WASTE QUARRY DUST AND MARBLE …

PDF | The research focuses on the effect of using waste marble powder and quarry dust as partial sand replacement materials on concrete properties. Massive exploitation of the nonrenewable natural ...

Experimental study on partial replacement of cement by ...

Abstract-The present study is aimed at utilizing Waste marble powder and quarry sand as partial replacement of cement and fine aggregate in concrete and comparing it with conventional concrete. This experimental investigation is carried out in three phases in 1st phase M20 grade of concrete is produced by replacing cement with 0%, 5%, 10% & 15% ...

Quikrete 47 lb. Marble Sand Mix-G040 - The Home Depot

Enjoy the QUICKRETE 50 lb. Marble Sand Mix G040, fine grit tackle tough projects requiring industrial-grade mortar from The Home Depot

Partial Substitution of Sand and Cement with Waste Marble ...

Oct 31, 2018· Abstract. This paper introduces the study on self-compacting concrete (SCC) using waste marble powder (WMP) as a partial substitution of sand along with waste limestone dust (WLSD) as a partial substitution for cement in addition to sugarcane molasses as an admixture.

Partial Replacement of Cement to Concrete by Marble Dust ...

Partial Replacement of Cement to Concrete by Marble Dust Powder and threatening both agriculture and public health. Therefore, utilization of the marble dust in various industrial sectors especially the construction, agriculture, glass and paper industries would help to protect the environment.

Review on the feasibility of Marble Dust as Replacement of ...

waste marble powder construction industry itself as fine aggregate replacing natural sand in concrete. The replacement is done partially and fully in the proportion 0%, 25%, 50% and and its effect on concrete properties were analyzed and outcomes that replacement of 50% of sand with marble powder is

Marble Powder As A Partial Replacement Of Sand - 1454 ...

Nov 26, 2016· Marble Powder As A Partial Replacement Of Sand 1454 Words Nov 26, 2016 6 Pages V. CONCLUSION From the test results it is clearly evident that granite powder as a partial replacement of sand proves to be beneficial when Durability properties of Concrete is considered.

Ppt On Partial Replacement Of Sand With Quarry Dust

Effect of Fly Ash on Mortar Mixes with Quarry Dust as Fine Aggregate. Usage of quarry dust as partial replacement to river sand/natural sand further modified by partial replacement of pozzolanic materials like fly ash is receiving more attention these days as their use generally improves the properties of cement/concrete.

Marble Powder As Fine Aggregates in Concrete | Memon ...

Marble powder (MP), produced from the marble industry is also increasing, which constantly remains a source of hazards to the environment. At the same time, natural sand deposits are decreasing, causing an acute need for a product that matches the properties of sand in concrete.

partial replacement of cement by marble dust pdf thesis ...

Nov 12, 2012· pdf replacement of sand with marble powder in green concrete … The use of waste marble powder (dust) was proposed in partial replacement … replacement of cement with marble powder pdf. Production of Self–compacting Concrete … »More detailed

Influence of Marble Dust as Partial Replacement of Cement ...

pastes were prepared using marble powder,with and without adding any super plasticizers and by varying the water to cement ratio. And results shows that 10% of sand can be replaced by marble powder provided maximum compressive strength at about same workability [ 3].

EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF …

Rakesh Gupta studied on "Partial replacement of cement with marble powder" and concluded that for M 20 grade concrete the compressive strength of cubes are increased with addition of waste marble powder up to 10% replace by weight of cement and further any addition of waste marble powder the compressive strength decreases.

Ceramic Waste : Effective Replacement Of Cement For ...

Ceramic Waste : Effective Replacement Of Cement For Establishing Sustainable Concrete Amitkumar D. Raval1, Dr.Indrajit N. Patel2, Prof. Jayeshkumar Pitroda3 1Student of final year M.E. C E & M, B.V.M. Engineering college, Vallabh Vidyanagar 2 Applied Mechenics Department, BBIT, Vallabh Vidyanagar …

Feasibility and Need of use of Waste Marble Powder in ...

reduces the slump of concrete mixes, whereas replacement of sand by marble waste powder up to 20% enhances the slump of the concrete mixes. In concrete production replacement of 5% cement by marble waste powder gives comparable compressive and flexural strength as of marble waste free

An Experimental Study of Mechanical Properties on Fibre ...

construction. Marble dusts and Fibres, the abundantly available materials were selected for partially replacements in concrete. Marble powder being a residual content is used in concrete with various proportions as a partial replacement of sand in the proportion of 15% and 20% by weight.

Partial Replacement of Cement to Concrete by Marble …

Partial Replacement of Cement to Concrete by Marble Dust Powder and threatening both agriculture and public health. Therefore, utilization of the marble dust in various industrial sectors especially the construction, agriculture, glass and paper industries would help to protect the environment.

EXPERIMENTAL STUDY OF CONCRETE BY PARTIAL …

natural sand by CRP at replacement levels of 20, 30& 40 percent. In this experimental study, the main objective is to study the influence of partial replacement of cement with granite powder, and to compare it with the compressive strength of ordinary M 25 grade concrete. Further, trying to …

(PDF) PARTIAL REPLACEMENT OF CEMENT WITH MARBLE DUST ...

This project describes the feasibility of using the marble sludge dust in concrete production as partial Sand: replacement of cement. In INDIA, the marble Natural sand which is easily available and low in processing is one of the most thriving industry the price was used in the work.

Experimental study of concrete made with granite and iron ...

The concrete mix made using granite powder (GP) and iron powder (IP) as partial replacement of sand showed good workability and fluidity similar to normal concrete mixes. 2. The compressive strength of concrete increased with the addition of granite powder (GP) as partial replacement of sand.

powerpoint presentation on marble powder - BINQ Mining

Dec 22, 2012· paper presentation on cement replacement by marble powder …. Characterization of marble powder for its use in mortar and concrete … A PowerPoint presentation … and reground to a fine powder to form Portland cement. … »More detailed

Effect on Partial Replacement of Fine Aggregate and Cement ...

Effect on Partial Replacement of Fine Aggregate and Cement by Waste Marble Powder/ Granules ….. 111 | Page III. Mix Proportion Sr. No Cement Sand Marble Powder Mix designation 1 0% MX0(control) 2 90% 10% MX1(Sand) 3 90% 10% MX2(cement)

Investigation on Strength Properties of Concrete with ...

fine aggregate (sand) and cement were partially replaced with Granite powder and marble powder. The replacement is done by 5%, 10%, 15%, 20%, 25% of cement by marble powder and 5%, 10%, 15%, 20%, 25% of fine aggregate by granite powder to evaluate the effect of presence of these replacement materials on the strength of specimens.

Effect on Partial Replacement of Fine Aggregate and …

Effect on Partial Replacement of Fine Aggregate and Cement by Waste Marble Powder/ Granules ….. 111 | Page III. Mix Proportion Sr. No Cement Sand Marble Powder Mix designation 1 0% MX0(control) 2 90% 10% MX1(Sand) 3 90% 10% MX2(cement)

The Effect of marble powder and silica fume as partial ...

replacement ratio of silica fume with cement content and in case of replacement marble powder with cement content the compressive strength increased by 22.7%, 27.8% at 7, and 28 days at 15% replacement ratio of marble powder with cement content respectively. Keywords: mortar, marble powder, silica fume, compressive strength. 1.

Project on Partial Replacement of Cement with Marble Powder

In this project our main objective is to study the influence of partial replacement of cement with marble powder, and to compare it with the compressive and tensile strength of ordinary M20 concrete. We are also trying to find the percentage of marble powder replaced in concrete that makes the strength of the concrete maximum.